Показать сокращенную информацию
dc.contributor.author | Антошкина, Е.Г. | |
dc.contributor.author | Смолко, В.А. | |
dc.contributor.author | Antoshkina, E.G. | |
dc.contributor.author | Smolko, V.A. | |
dc.date.accessioned | 2020-05-18T04:48:19Z | |
dc.date.available | 2020-05-18T04:48:19Z | |
dc.date.issued | 2017 | |
dc.identifier.citation | Антошкина, Е.Г. Влияние ультразвуковой обработки на вязкость водно-глинистых суспензий для песчано-глинистых смесей / Е.Г. Антошкина, В.А. Смолко // Вестник ЮУрГУ. Серия «Металлургия». – 2017. – Т. 17, № 2. – С. 34–40. DOI: 10.14529/met170204. Antoshkina E.G., Smolko V.A. Influence of Ultrasonic Treatment on the Viscosity of Aqueous-Clay Suspensions for Sand-Clay Mixtures. Bulletin of the South Ural State University. Ser. Metallurgy, 2017, vol. 17, no. 2, pp. 34–40. (in Russ.) DOI: 10.14529/met170204 | ru_RU |
dc.identifier.issn | 2411-0906 | |
dc.identifier.uri | http://dspace.susu.ru/xmlui/handle/0001.74/27214 | |
dc.description | Антошкина Елизавета Григорьевна, канд. техн. наук, доцент кафедры теоретической и прикладной химии, Южно-Уральский государственный университет, г. Челябинск; antoshkinaeg@ susu.ru. Смолко Виталий Анатольевич, д-р техн. наук, профессор кафедры теоретической и прикладной химии, Южно-Уральский государственный университет, г. Челябинск; smolkova@ susu.ru. E.G. Antoshkina, antoshkinaeg@susu.ru, V.A. Smolko, smolkova@susu.ru South Ural State University, Chelyabinsk, Russian Federation | ru_RU |
dc.description.abstract | Статья посвящена исследованию влияния частоты и времени ультразвуковой обработки на вязкость бентонитовых водно-глинистых суспензий. Объектом исследования являлась бентонитовая глина Зыряновского месторождения Курганской области, на основе которой готовились водно-глинистые суспензии. Полученные суспензии исследовали на условную вязкость, для определения которой использовался вискозиметр ВЗ-2, и динамическую вязкость, которую определяли при помощи ротационного вискозиметра Brookfield Rheo V 2.8. При ультразвуковой обработке дисперсная система условно делится на четыре зоны: зону активного диспергирования твердой фазы, переходную зону, зону волновой и гидродинамической коагуляции и зону устойчивого структурно-реологического равновесия состояния твердой фазы раствора. Показано, что обработка глинистых суспензий ультразвуком вызывает в зависимости от продолжительности и мощности обработки как диспергирующее, так и агрегатирующее действие. Ультразвуковая обработка в течение 15 мин приводит к снижению условной вязкости водно-глинистых суспензий из-за образования периодических коллоидных структур, после чего начинается процесс автокаогуляции. В результате ультразвукового воздействия полем 20 кГц на водно-глинистые суспензии зыряновского бентонита в течение 1, 5 мин происходит уменьшение динамической вязкости вследствие диспергации частиц, а в результате ультразвукового воздействия полем 50, 60 кГц на водно-глинистые суспензии зыряновского бентонита в течение 1, 5 мин происходит увеличение динамической вязкости, что связано с коагуляцией частиц. Установлено, что устойчивость активированных коагуляционных систем к механическим нагрузкам значительно меньше, чем у исходных бентонитовых глин, что позволяет осуществить более равномерное распределение глинистых минералов по поверхности кварцевого песка и обеспечить увеличение количества когезионно-адгезионных контактов и повышение физико-механических свойств смесей при формообразовании. The article considers the influence of the frequency and time of the ultrasonic treatment on the viscosity of the bentonite suspensions. The object of the study is the bentonite clay of Zyryansk deposit; on the basis of it water-clay suspensions were prepared. The suspensions were examined for conditional viscosity, which was determined by the viscometer VZ-2 and for the dynamic viscosity which was determined by using the rotary viscometer Brookfield Rheo V 2.8. In processing the dispersion system is divided into four zones: the zone of active dispersion of the solid phase, the transitional zone, wave and hydrodynamic coagulation zone and sustainable structural and rheological equilibrium state of the solid solution phase. It has been shown that the treatment of clay suspensions by the ultrasonic treatment depending on the time and processing power causes both dispersant and aggregated action. It is established that the water-bentonite clay suspensions are the thixotropic non- Newtonian fluids with pseudoplastic flow. The ultrasonic treatment during 15 minutes leads to the decrease in the relative viscosity of the suspensions by reason of formation of the periodic colloidal structures, after which the process of the autocoagulation begins. The ultrasonic treatment by field of 20 kHz during 1, 5 minutes leads to the decrease in the dynamic viscosity of the suspensions by reason of dispersion of the particles. The ultrasonic treatment by field of 50, 60 kHz during 1, 5 minutes leads to the increase in the dynamic viscosity of the suspensions by reason of coagulation of the particles. It is established that the stability of the activated coagulation system to mechanical stress is considerably smaller than the original bentonite clays that allows to realize for more uniform distribution of the clay minerals over the surface of the quartz sand and provides increasing the number of the cohesive and adhesive contacts and improving the physical and mechanical properties of the mixtures in forming. | ru_RU |
dc.language.iso | other | ru_RU |
dc.publisher | Издательский центр ЮУрГУ | ru_RU |
dc.relation.ispartof | Вестник ЮУрГУ. Серия Металлургия | |
dc.relation.ispartof | Vestnik Ûžno-Ural’skogo gosudarstvennogo universiteta. Seriâ, Metallurgiâ | |
dc.relation.ispartof | Bulletin of SUSU | |
dc.relation.ispartofseries | Металлургия;Том 17 | |
dc.subject | УДК 621.742.4 | ru_RU |
dc.subject | водно-глинистая суспензия | ru_RU |
dc.subject | ультразвуковая обработка | ru_RU |
dc.subject | условная вязкость | ru_RU |
dc.subject | динамическая вязкость | ru_RU |
dc.subject | aqueous-clay suspension | ru_RU |
dc.subject | ultrasonic treatment | ru_RU |
dc.subject | conditional viscosity | ru_RU |
dc.subject | dynamic viscosity | ru_RU |
dc.title | Влияние ультразвуковой обработки на вязкость водно-глинистых суспензий для песчано-глинистых смесей | ru_RU |
dc.title.alternative | Influence of Ultrasonic Treatment on the Viscosity of Aqueous-Clay Suspensions for Sand-Clay Mixtures | ru_RU |
dc.type | Article | ru_RU |
dc.identifier.doi | DOI: 10.14529/met170204 |